【摘要】 用加压活性污泥法处理有机中间体废水,考查了停留时间、污泥浓度、反应压力及曝气量等条件对化学需氧量(COD)去除率的影响,并对生物降解动力学进行了研究.有机中间体废水经铁炭床微电解预处理后,CODCr从原水的8 000 mg/L降到4 000~5 000 mg/L,B/C由原来的0.20升高到0.40左右.通过实验确定了加压活性污泥法处理有机中间体废水的较优工艺条件为:反应器内废水CODCr在1 800~2 100 mg/L,反应压力0.1 MPa,污泥浓度4.0~6.0 g/L,停留时间8~10h,曝气量2.0 L/min.此条件下COD去除率大于70%,出水CODCr小于600 mg/L.生物降解动力学符合Monod模式,动力学参数:Vmax24.49 d-1,KS1 927.69 mg/L.更多还原

【Abstract】 The treatment of organic intermediate wastewater by pressurized activated sludge process was researched.The effect of the experiment parameters,such as the aeration time,the mixed liquor suspended solids（MLSS） concentration and the pressure,on the chemical oxygen demand（COD） removal was investigated.The COD_Cr decreased from 8 000 mg/L to 4 000⁵ 000 mg/L and BOD/COD increased from 0.2 to 0.4 after the organic intermediate wastewater was pre-treated by ferric carbon micro electrolysis.For the wastewater with an initial COD_Cr at 1 800² 000 mg/L the optimal experiment conditions were determined as follows: pressure 0.1 MPa,MLSS 4.0⁶.0 mg/L,aeration time 8¹0 h,aeration flux 2.0 L/min.Under these conditions more than 70% COD_Cr could be removed and the effluent COD_Cr was less than 600 mg/L.The biodegradation can be described by Monod Equation,and the kinetics parameters are V_max 24.49 d^-1,K_S 1 927.69 mg/L.更多还原