【摘要】 在环氧树脂涂料中掺杂不同含量不同长度的碳纤维填料,并对涂层表面进行绝缘化处理,分别在11和15 kV电压条件下,检测其对黄杆菌的杀灭效果。结果表明:当涂层中不含碳纤维时,在11和15 kV电压作用下,其杀菌率分别为90.82%和93.18%。在11 kV电压和含0.01%(质量分数)碳纤维时,杀菌效果随碳纤维长度的增大而略为增大,填料长度为7 mm的碳纤维涂层杀菌率为99.82%。而在11 kV电压和含0.03%碳纤维时,填料长度为3 mm的碳纤维涂层在该条件下杀菌效果最为理想,为99.73%。电压越大,则杀菌效果越好。高压脉冲电场作用下的导电涂料有可能成为一种新型环保节能的防污技术。Raman和SEM结果表明,高压脉冲电场对涂层有序度和完整性略有影响。更多还原

【Abstract】 Epoxy resin coatings reinforced with different amount of carbon fiber of varied length were prepared, and which then were covered with a top coating of insulation. The antibacterial performance of the above coatings, especially for flavobacterium was examined by high voltages of 11 and 15 kV respectively. It was observed that the sterilizing efficiency of epoxy resin coatings without carbon fiber were 90.82% and 93.18% by voltage 11 and 15 kV respectively. For the coating with 0.01%(mass fraction) of carbon fiber, the sterilizing efficiency increases slightly with the increasing fiber length by voltage 11 kV. The epoxy resin coatings with carbon fiber of 7 mm in length achieved a sterilizing efficiency up to 99.82%. While the epoxy resin coatings containing 0.03% carbon fiber of 3 mm in length exhibits the highest sterilizing efficiency 99.73% by voltageof 11 kV; whilst the sterilizing efficiency of the epoxy resin coatings increased with the increasing voltage. Therefore, the conductive epoxy resin coating may provide a new prospect for environment-friendly and energy-saving technique of fouling prevention in the relevant industrial processes, which adopt pulse electric field technology.更多还原